中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 升温过程干法半干法脱硫灰中硫酸盐的稳定性研究 安徽农业科学 2010,38 (2) 321-322+350
Position: Home > Articles > Study on the Stability of Sulfate in Desulfurization Residues Produced by Dry and Semi-dry Methods during Heating Process Journal of Anhui Agricultural Sciences 2010,38 (2) 321-322+350

升温过程干法半干法脱硫灰中硫酸盐的稳定性研究

作  者：
王现菊;石林
单  位：
华南理工大学环境科学与工程学院
关键词：
硫酸盐;脱硫灰渣;焙烧;亚硫酸钙
摘  要：
[目的]研究不同气氛、湿度和温度对脱硫灰中硫酸盐稳定性的影响。[方法]通过改变气氛、脱硫灰湿度、焙烧温度的条件,研究干法和半干法脱硫灰中硫酸盐的稳定性。[结果]在空气条件下,当焙烧温度为450~700℃时,脱硫灰中的CaSO3能迅速氧化成性质稳定的CaSO4;当焙烧温度为750~1 050℃时,脱硫灰中的CaSO3能同时发生氧化和分解,部分CaSO3分解为CaO和SO2。在氮气条件下,CaSO3在650℃开始分解。随着脱硫灰湿度的增加,SO2的逸出量越大,CaSO3的分解率越大,同时由CaSO4的分解产生SO2。在800~1 050℃,SO2的逸出量随着温度的升高而增加。[结论]450~1 050℃,SO2的最大排放浓度为101.4 mg/m3,远远低于国家标准(800mg/m3),在脱硫灰渣的再利用中对环境不会造成危害。
译  名：
Study on the Stability of Sulfate in Desulfurization Residues Produced by Dry and Semi-dry Methods during Heating Process
作  者：
WANG Xian-ju et al (College of Environmental Science and Engineering,South China University of Technology,Guangzhou,Guangdong 510006)
关键词：
Sulfate;Desulfurization residues;Calcinations;CaSO3
摘  要：
[Objective] The purpose was to study the effects of different atmosphere,humidity and temperature on stability of sulfite in flue gas desulfurization(FGD) residues made by dry and semi-dry method in the heating process.[Method] The stability of sulfite in FGD residues produced by dry and semi-dry methods in the heating process was studied through changing the atmosphere,the humidity of FGD residues and the temperature of calcination.[Result] In air,when the temperature of calcination was 450-700 ℃,CaSO3 in FGD residues was quickly oxidized into stable CaSO4;when the temperature of calcination was 750-1 050 ℃,CaSO3 in FGD residues could occur the oxidation and decomposition simultaneously and some CaSO3 was decomposed into CaO and SO2.In N2,CaSO3 could begin to be decomposed at 650 ℃.With the rising of the humidity of FGD residues,the greater the escaped amount of SO2 was,the bigger the decomposition rate of CaSO3 was and then SO2 could occur from the decomposition of CaSO4 at same time.In the rang of 800-1 050 ℃,with the rising of the temperature,the emission amount of SO2 was increased.[Conclusion] In the range of 450-1 050 ℃,the maximum emission concn.of SO2 by calcining the FGD residues was 101.4 mg/m3,which was far lower than the national standards(800 mg/m3)and didn't make any damage to the environment when the FGD residues was used again.

相似文章

导出引用
计量
文章访问数: 4
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46