中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 叶片交错布置对双吸泵空化性能的影响分析 农业机械学报 2017 (12) 124-131+140
Position: Home > Articles > Effects of Staggered Blades on Cavitation Characteristics of Double-suction Centrifugal Pump Transactions of the Chinese Society for Agricultural Machinery 2017 (12) 124-131+140

叶片交错布置对双吸泵空化性能的影响分析

作  者：
韩伟;郑昊;王丽琼;张振中;苏敏
关键词：
双吸离心泵;交错叶片;空化;数值模拟
摘  要：
为研究叶片交错布置对双吸离心泵空化性能的影响,选用RNG k-ε湍流模型和基于Rayleigh-Plesset方程的空化模型,考虑泵腔和工艺圆角的影响,分别对叶片交错角为0°、10°、15°、20°、30°的5组角度在设计工况下进行了全流场空化流动模拟和性能试验。为突出研究结论的共性,引入交错度的定义,并分析了不同交错度下叶轮中间流面的空泡分布、扬程和叶轮扭矩变化,同时验证了所选数值计算模型的准确性;从数值分析中得到,选择合理的交错度可以有效提高双吸离心泵的抗空化性能。不同交错度下叶轮所受扭矩急剧下降时对应的有效空化余量均不同,当交错度为1时,叶轮所受扭矩在未空化时较为稳定且在空化时损失较少;当有效空化余量小于临界空化余量时,双吸离心泵叶轮流道内低于当地空化压力的区域,交错度为1时相对最少,即空泡占据流道过流面积最少,此时双吸叶轮的空化特性也相对较好。
译  名：
Effects of Staggered Blades on Cavitation Characteristics of Double-suction Centrifugal Pump
作  者：
HAN Wei;ZHENG Hao;WANG Liqiong;ZHANG Zhenzhong;SU Min;School of Energy and Power Engineering,Lanzhou University of Technology;Key Laboratory of Fluid Machinery and System of Gansu Province;Shandong Shuanglun Co.,Ltd.;College of Electrical and Information Engineering,Lanzhou University of Technology;
关键词：
double-suction centrifugal pump;;staggered blades;;cavitation;;numerical simulation
摘  要：
In order to identify effects of staggered blades on cavitation characteristics of double-suction centrifugal pump,considering the influence of the shrouds of pump and fillet,the blades of both sides of the impeller were separated circumferentially at 0°,10°,15°,20° and 30° staggered angles,respectively.RNG k-ε turbulence model and Rayleigh-Plesset equation were applied to simulate cavitation characteristics and performance test under design conditions. In order to highlight the generality of the research conclusion,the definition of staggered degree was introduced and the vapor volume fraction on the middle stream surface of impeller and head and the variation of the impeller torque at different staggered degrees were analyzed. Compared with experimental values,the results indicated that the prediction results were accurate to some extent; it can be seen that the selection of reasonable staggered degree can improve the performance of anti-cavitation. At different staggered degrees,the corresponding net positive suction head values were different when the impeller torque was subjected to a sharp decrease,when the staggered degree was at 1,the impeller torque was stable in cavitation and relatively less in cavitation; when net positive suction head was under critical net positive suction head,the region of static pressure was lower than the local cavitation pressure at the double-suction centrifugal pump impeller channel and the vapor occupied the least flow area at the flow channel,staggered degree at 1 was the least. Therefore,the cavitation characteristics were relatively good when the staggered degree was at 1 to provide a theoretical basis for improving the cavitation characteristics and the safe operation of doublesuction centrifugal pump.

相似文章

导出引用
计量
文章访问数: 21
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46