中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 催化微燃烧室内氢气和氧气预混合燃烧特性 农业机械学报 2016,47 (2) 357-363
Position: Home > Articles > Combustion Characteristic of Premixed Hydrogen / Oxygen Mixture in Catalytic Micro-combustor Transactions of the Chinese Society for Agricultural Machinery 2016,47 (2) 357-363

催化微燃烧室内氢气和氧气预混合燃烧特性

作  者：
潘剑锋;刘启胜;卢青波;潘振华
单  位：
江苏大学能源与动力工程学院
关键词：
微尺度燃烧;数值模拟;吹熄极限;表面反应;气相反应
摘  要：
针对带催化的微燃烧室内部氢氧预混合燃烧过程,利用CFD计算软件建立模型进行数值模拟,在实验验证的基础上改变入口参数,分析了表面反应与气相反应的相互作用以及催化反应对火焰吹熄极限的影响。结果表明,表面反应对气相反应中间产物的消耗会使气相反应强度减弱;在催化剂表面附近的反应以表面反应为主,在远离催化剂表面的反应以气相反应为主。催化剂的添加能够极大地拓宽火焰吹熄极限,在当量比为1.0时,催化燃烧室和无催化燃烧室的吹熄极限分别为46、22 m/s。在当量比为1.0时,表面反应强度最高,此时燃烧室出口截面温度最高。
译  名：
Combustion Characteristic of Premixed Hydrogen / Oxygen Mixture in Catalytic Micro-combustor
作  者：
Pan Jianfeng;Liu Qisheng;Lu Qingbo;Pan Zhenhua;School of Energy and Power Engineering,Jiangsu University;
关键词：
micro-scale combustion;;numerical simulation;;blow-off limit;;surface reaction;;gas-phase reaction
摘  要：
The premixed hydrogen / oxygen combustion process in a catalytic micro-combustor was numerically simulated with CFD software. The interaction between gas-phase and catalytic reaction was analyzed by changing inlet parameters on the basis of experimental verification. Meanwhile,the blow-off limits for combustor with and without catalyst were also investigated. The results showed that gas-phase reaction was subdued with the intermediate products consumed in catalytic reaction. At the same velocity,the flame temperature of catalytic combustor was lower than that of non-catalytic combustor. The OH mass fraction near up-wall of Pt cell in catalytic combustion chamber was also lower than that near up-wall of Si C cell in non-catalytic combustor. While owing to the exothermic surface reaction with Pt cell,the temperature of Pt cell in catalytic combustor was higher than that of Si C cell in non-catalytic combustor. Catalytic reaction was dominant near the surface of catalyst,while gas-phase reaction was dominant away from the surface. The OH mass fraction distribution trend near the inner up-wall in catalytic combustor was consistent with that near the inner up-wall in non-catalytic combustor. The blowoff limit can be widened by adding catalyst. The blow-off limits for combustor with and without catalyst were 46 m / s and 22 m / s,respectively. At equivalence ratio of 1. 0,the strongest activity of catalytic was shown,and the gas-phase reaction was obviously restrained. With the increase of equivalence ratio,the mean temperature of out-wall was risen at the beginning and then it was dropped later. The highest mean temperature of out-wall was achieved with equivalence ratio of 1. 0.

相似文章

导出引用
计量
文章访问数: 12
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46