中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 重结晶法提纯番茄红素的研究 农机化研究 2006 (10) 151-155
Position: Home > Articles > Research on Purifying Lycopene by Recrystallization Journal of Agricultural Mechanization Research 2006 (10) 151-155

重结晶法提纯番茄红素的研究

作  者：
梅晓岩;孟宪军;梁婧婧
单  位：
沈阳农业大学食品学院
关键词：
园艺学;番茄红素;试验研究;重结晶;提纯;DSC;HPLC
摘  要：
以6%番茄红素油树脂为原料,用重结晶法制备出番茄红素晶体,考察了温度、皂化时间、不同溶剂和重结晶级数对得率及纯度的影响。结果表明,用正己烷作分散剂、无水乙醇作助剂,在70℃条件下皂化60min,水洗正己烷层至中性,真空挥去部分溶剂,冷却滤出番茄红素晶体溶于65℃乙酸乙酯中至饱和,缓慢降温至0℃析出晶体。对样品紫外、红外扫描得到的色谱图具有典型的特征峰,重结晶3次样品HPLC分析保留时间与标准品一致,所得样品为全反式番茄红素,HPLC法测纯度达104.03%,差示扫描量热法分析纯度达99.17%,总得率为24.7%。本研究为高纯度番茄红素的获得提供了一条有效途径。
译  名：
Research on Purifying Lycopene by Recrystallization
作  者：
MEI Xiao-yan,MENG Xian-jun,LIANG Jing-jing (College of Food Science, Shenyang Agricultural University, Shenyang 110161, China)
关键词：
garderning; lycopene; experiment research; recrystallization; purify; DSC; HPLC
摘  要：
Crystal of lycopene was prepared by recrystallization when a content of 6% lycopene oleoresin was used as raw material. Effect of temperature, time of saponification, solvent and order of recrystallization on yield and purity of lycopene was carried out. Results showed that the preparation process was as follows: when hexane and ethanol were used as scattering and aid agents respectively, the raw material was saponified 60 min at 70℃, and hexane was washed until neutral; and then the raw material was cooled and filtered after some solvent was evaporated at vacuum condition; after that it dissolved in ethyl acetate at 65℃ until saturates; finally the crystal can be produced when it was cooled slowly till 0℃. Mass spectrogram by UV-scan and infrared spectrophotometry of prepared lycopene sample had typical peaks. The retention time of sample after 3 times of recrystallization was the same as that of standard sample by HPLC. The lycopene prepared was proved to be all-trans conformation. Its purities were 104.03% and 99.17% by HPLC and DSC analysis, respectively. Its total yield was 24.7%. The research has provided a useful method for obtaining high purity lycopene.

相似文章

导出引用
计量
文章访问数: 6
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46