中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 蒸发法处理厌氧发酵沼液试验研究 农业机械学报 2015,46 (5) 164-170
Position: Home > Articles > Evaporation Treatment on Biogas Slurry from Anaerobic Fermentation Transactions of the Chinese Society for Agricultural Machinery 2015,46 (5) 164-170

蒸发法处理厌氧发酵沼液试验研究

作  者：
白晓凤;李子富;尹福斌;程世昆;白雪;张扬
单  位：
北京科技大学土木与环境工程学院
关键词：
沼液;蒸发;浓缩;减压;营养物质回收
摘  要：
采用蒸发法浓缩处理沼液,研究了低温蒸发、常压蒸发和减压蒸发过程对沼液浓缩的影响。结果表明:不同温度下(常温、25℃、35℃、45℃、55℃、65℃、75℃、85℃)低温蒸发对浓缩沼液的氨氮质量浓度有较大影响,氨氮在蒸发过程中几乎全部损失(98%),对浓缩液营养物质的回收不利。沼液在不同p H值(2、3、4、5、6、7)的常压蒸发研究表明,当初始p H值小于等于4时,冷凝水的氨氮质量浓度低于41.0 mg/L,水质可以满足GB 18596—2001《畜禽养殖业污染物排放标准》。减压蒸发试验结果表明,相对真空度-0.03~-0.08 MPa对沼液蒸发过程影响不大。沼液不同初始p H值的减压试验结果表明,与常压蒸发相比,减压蒸发可以降低冷凝水中的氨氮质量浓度和化学需氧量(COD),提高冷凝水水质。减压蒸发在沼液初始p H值小于等于5时,冷凝水氨氮质量浓度在61.8 mg/L以下,可满足排放标准。因此,真空蒸发对整个系统的运行最为有利。
译  名：
Evaporation Treatment on Biogas Slurry from Anaerobic Fermentation
作  者：
Bai Xiaofeng;Li Zifu;Yin Fubin;Cheng Shikun;Bai Xue;Zhang Yang;School of Civil and Environmental Engineering,University of Science and Technology Beijing;Beijing Key Laboratory of Resource-oriented Treatment of Industrial Pollutants,University of Science and Technology Beijing;
关键词：
Biogas slurry Evaporation Concentration Vacuum Nutrient recycling
摘  要：
Evaporation was applied to concentrate biogas slurry. The effects of low temperature evaporation,atmospheric evaporation and vacuum evaporation on biogas slurry concentration were investigated. Results showed that the low temperature evaporation( room temperature,25℃,35℃,45℃,55℃,65℃,75℃,85℃) had a great impact on the ammonia nitrogen concentration of biogas slurry,and almost all ammonia( 98%) were lost,which has disadvantages on the recovery of nutrients.It showed that when the initial p H value was less than 4 in atmospheric evaporation,the water quality of the effluent( ammonia is lower than 41. 0 mg / L) could meet the demand of Discharge Standard of Pollutants for Livestock and Poultry Breeding( GB 18596—2001). Experimental results of the vacuum evaporation showed that vacuum degree(- 0. 03 ~- 0. 08 MPa) had little influence on evaporation results. Vacuum evaporation of biogas slurry with different initial p H value showed that compared with the atmospheric evaporation,vacuum evaporation could reduce the content of ammonia nitrogen and chemical oxygen demand( COD) in effluent and improve quality of effluent. When the initial p H value of biogas slurry in vacuum evaporation process was less than 5,the effluent( ammonia is lower than 61. 8 mg / L)could meet the discharge standard. Therefore,the most effective operation for the whole system is vacuum evaporation.

相似文章

导出引用
计量
文章访问数: 11
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46