中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > PY_1 40型摇臂式喷头摇臂碰撞过程数值模拟 农业机械学报 2010,41 (1) 92-97
Position: Home > Articles > Numerical Simulation of Swing Arm Impact Process to the PY_1 40 Impact Sprinkler Transactions of the Chinese Society for Agricultural Machinery 2010,41 (1) 92-97

PY_1 40型摇臂式喷头摇臂碰撞过程数值模拟

作  者：
王祺铭;严海军;剧锦三;刘长云
单  位：
中国农业大学水利与土木工程学院
关键词：
摇臂式喷头;碰撞;有限元模拟;动应力
摘  要：
基于显式动力分析软件ANSYS/LS-DYNA,建立了摇臂式喷头摇臂绕轴旋转、碰撞喷体的有限元分析模型,在3种摇臂转动角速度和喷体安装弹性橡胶垫与否的组合工况下,对摇臂与喷体的碰撞过程及动应力分布进行了计算模拟。结果表明,PY1 40型摇臂式喷头在转动角速度400(°)/s时,计算的碰撞动应力峰值为42.3 MPa,与试验值的误差小于0.5%,预测的发生位置距离摇臂转轴中心15 cm,与试验结果相同。摇臂各断面的动应力极值和碰撞接触应力均随转动角速度的增加而增大,喷体打击块安装橡胶垫后,3种转动角速度下动应力峰值平均降低了10.4%,但接触时间平均增加了76.6%。
译  名：
Numerical Simulation of Swing Arm Impact Process to the PY_1 40 Impact Sprinkler
作  者：
Wang Qiming Yan Haijun Ju Jinsan Liu Changyun(College of Water Conservancy and Civil Engineering,China Agricultural University,Beijing 100083,China)
关键词：
Impact sprinkler,Impact,Finite element simulation,Dynamic stress
摘  要：
As one of the key parts of the impact sprinkler,the swing arm is exerted by complex dynamic stress in the impact process.Based on the dynamic explicit software ANSYS/LS-DYNA,a finite-element model for simulating the rotation of swing arm around the axis and the impact between the swing arm and the sprinkler body was established.Several cases under three rotational angular velocities and with or without the rubber pad fixed on the sprinkler body's contact stop were investigated.The results indicate that under the angular velocity of 400(°)/s, the simulated peak dynamic stress of PY1 40 impact sprinkler was 42.3 MPa,with an error less than 0.5% compared with the measured result.The predicted peak dynamic stress was located offset 15 cm from the centerline of the swing arm's rotation axis,which was the same as the measured data.The extreme dynamic stresses of different cross sections and contact stresses increased with the increase of the rotational angular velocity.After fixing the rubber pad,the peak dynamic stress had an average decrease of 10.4% under three angular velocities,while the contact time had an average increase of 76.6%.

相似文章

导出引用
计量
文章访问数: 11
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46