中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 硫酸盐黑液热解特性分析 农业机械学报 2009,40 (10) 92-97
Position: Home > Articles > Experiment of Kraft Black Liquor Pyrolysis Characteristics Transactions of the Chinese Society for Agricultural Machinery 2009,40 (10) 92-97

硫酸盐黑液热解特性分析

作  者：
袁洪友;阴秀丽;李志文;周肇秋;吴创之;武书彬
单  位：
华南理工大学制浆造纸工程国家重点实验室;中国科学院可再生能源与天然气水合物重点实验室
关键词：
黑液;热解;膨胀;硫释放
摘  要：
采用可视化单液滴反应器观察硫酸黑液在400～800℃范围内的热解膨胀行为,判断较低和较高温度下的不同膨胀特性。测定了3种硫酸盐黑液在450～850℃范围内热解永久性气体中H_2、CO、CO_2和CH_4相对含量,考察热解气体中大量H_2的主要来源。热解导致的总硫释放量通过对热解焦的分析得到,并用碘量法确定了气相中H_2S含量。结果表明:高于500℃时,黑液膨胀至最大体积后将开始收缩,而低于此温度则膨胀至最大体积后保持不变;黑液热解永久性气体中H_2的含量较高,在惰性载气连续吹扫的情况下,水蒸气并未参与热解焦气化反应,几乎全部的H_2均来自黑液有机物的分解;低于650℃时总硫与H_2S释放量随温度升高而增加,而高于此温度时释放量反而逐渐减少。
译  名：
Experiment of Kraft Black Liquor Pyrolysis Characteristics
作  者：
Yuan Hongyou~(1,2) Yin Xiuli~1 Li Zhiwen~(1,2) Zhou Zhaoqiu~1 Wu Chuangzhi~1 Wu Shubin~3 (1.The Renewable Energy and Gas Hydrate Key Laboratory,Chinese Academy of Sciences,Guangzhou 510640,China 2.Graduate University of Chinese Academy of Sciences,Beijing 100039,China 3.State Key Laboratory of Pulp and Paper Engineering,South China University of Technology,Guangzhou 510640,China)
关键词：
Black liquor;;Pyrolysis;;Swelling;;Sulfur release
摘  要：
Black liquor pyrolysis/gasification is a promising alternative for conventional combustion method. The swelling of kraft black liquor was tested at 400～800℃under nitrogen atmosphere with a visualized single droplet reactor.The main permanent pyrolysis gas components of three kraft black liquors were investigated at temperatures up to 850℃.The measurements of hydrogen sulfide release during pyrolysis were realized by iodometry,the total sulfur release was evaluated through char analysis.At the runs which temperatures higher than 500℃,the droplet volumes began decrease after the droplets swelled to the maximums.Water contents of the black liquors had no significant effects on the hydrogen yields under the reaction atmosphere where nitrogen was used as carrier gas,so nearly all the hydrogen was generated from organic components at the considered experimental conditions.The hydrogen sulfide release has similar trend to total sulfur release,i.e.,the release contents reached to the maximums at about 650℃,and below or above this temperature range they decreased.

相似文章

导出引用
计量
文章访问数: 10
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46