中国农业科学院农业信息研究所 中国农学会
Agricultural Information Institute of CAAS China Association of Agricultural Science Societies
En
Ch
中国农业科学院农业信息研究所 中国农学会 主办

AI检索

订阅

返回顶部
当前位置: 首页 > 文章 > 响应面法优化蒸汽爆破小麦秸秆工艺 中国畜牧兽医 2020 (6) 1765-1772
Position: Home > Articles > Optimization of Steam Explosion Pretreated Wheat Straw Using Response Surface Methodology China Animal Husbandry & Veterinary Medicine 2020 (6) 1765-1772

响应面法优化蒸汽爆破小麦秸秆工艺

作  者：
杜春梅;熊本海
单  位：
关键词：
Box-Behnken试验;蒸汽爆破;小麦秸秆;产气速率
摘  要：
试验旨在利用Box-Behnken响应面法优化蒸汽爆破预处理小麦秸秆最佳条件,从而解决小麦秸秆营养成分利用率较低的问题。选取蒸汽压强(1.5～2.5 MPa)、水分含量(10%～50%)和维压时间(90～210 s)为自变量,瘤胃体外发酵产气速率为响应值,利用响应面建立回归模型并进行回归方程拟合,预测最佳工艺参数。结果显示:维压时间对瘤胃体外发酵产气速率的影响极显著(P<0.01),蒸汽压强和水分含量对瘤胃体外发酵产气速率无显著影响(P>0.05)。由F值可知:3个自变量对瘤胃体外发酵产气速率的影响大小依次为维压时间、蒸汽压强和水分含量。Box-Behnken响应面法优化蒸汽爆破预处理小麦秸秆的最优工艺参数为蒸汽压强1.77 MPa、水分含量49.91%和维压时间209.98 s。此条件下瘤胃体外发酵产气速率可达0.0794 mL/h。3次平行试验验证的体外发酵产气速率为0.0786 mL/h,与理论预测值误差仅为1.02%。将小麦秸秆在最佳爆破条件下重新爆破并进行体外发酵试验,与未蒸汽爆破的小麦秸秆相比,蒸汽爆破极显著降低了小麦秸秆中中性洗涤纤维(NDF)、酸性洗涤纤维(ADF)和半纤维素的含量(P<0.01),同时极显著提高了体外发酵液中挥发性脂肪酸(VFA)和NH_3-N的含量(P<0.01)。综上,采用响应面法优化蒸汽爆破小麦秸秆的条件合理可行,优化的蒸汽爆破参数可用于提高小麦秸秆营养价值的蒸汽爆破工艺中。
译  名：
Optimization of Steam Explosion Pretreated Wheat Straw Using Response Surface Methodology
作  者：
DU Chunmei;XIONG Benhai;State Key Laboratory of Animal Nutrition,Institute of Animal Sciences,Chinese Academy of Agriculture Sciences;
关键词：
Box-Behnken design;;steam explosion;;wheat straw;;gas production rate
摘  要：
The purpose of this study was to optimize the parameters of steam explosion pretreatment of wheat straw by Box-Behnken response surface method,in order to solve the problem of its low utilization rate.The steam pressure(1.5-2.5 MPa),moisture content(10%-50%) and treatment time(90-210 s) were choosed as the independent variables,the rate of gas production in the in vitro rumen fermentation was the response value,and then the regression model were established and fitted.The results demonstrated that the influence of the treatment time on the rate of gas production in the in vitro rumen fermentation was extremely significant(P<0.01).The effect of steam pressure and moisture content on the rate of gas production in the in vitro rumen fermentation was not significant(P>0.05).According to the F value,the effect of three factors on the rate of gas production in the in vitro rumen fermentation was as treatment time>steam pressure >moisture content.The optimal conditions for steam explosion pretreatment by response surface methodology were steam pressure 1.77 MPa,moisture content 49.91% and treatment time 209.98 s.Under this condition,the rate of gas production in the in vitro rumen fermentation could reach 0.0794 mL/h.The average rate of gas in vitro was 0.0786 mL/h and the relative error was only 1.02%.The wheat straw was treated under the optimal steam explosion condition and subjected to in vitro rumen fermentation.Compared with untreated wheat straw,steam explosion extremely significantly decreased the content of NDF,ADF and hemicellulose in wheat straw(P<0.01),and extremely significantly increased the yield of VFA and NH_3-N in vitro rumen incubation(P<0.01).In conclusion,the operational parameter of steam explosion was optimized using the response surface method,which was reasonable and reliable.The steam explosion condition optimized in the present study could improve the nutritional value of wheat straw as forage.

相似文章

导出引用
计量
文章访问数: 16
HTML全文浏览量: 0
PDF下载量: 0

所属期刊

推荐期刊

友情链接Friendly link
农业信息研究所Agricultural information institute 农业智能知识服务平台Agricultural intelligent knowledge service platform 农业学术服务平台Agricultural Knowledge Service System 中国知网CNKI 维普网VIP 万方WANFANG DATA
联系我们Contact us

电话Tell：010-82109652-808

邮箱E-mail：agrijournal@caas.cn

服务Service
关于我们About us 意见建议Opinions and suggest
版权说明Copyright
单位：中国农业科学院农业信息研究所 中国农学会 © 2017中国农业科学院农业信息研究所 ICP备案号：京ICP备09089781号-46